TM 5-3805-248-23-2
OPERATOR COMPARTMENT REPLACEMENT
THIS WORK PACKAGE COVERS
Removal, Cleaning and Inspection, Installation
INITIAL SETUP
Equipment Condition - Continued
Maintenance Level
Dash panel circuit breakers removed (WP 0070 00)
Direct Support
Worklight, high beam, low beam and backup alarm
Tools and Special Tools
relays removed (WP 0078 00)
Tool kit, general mechanic's (Item 113, WP 0338
Headlamp dimmer switch removed (WP 0079 00)
Turn signal flasher removed (WP 0081 00)
Bracket, link (Item 10, WP 0338 00)
Backup alarm removed (WP 0100 00)
Lifting device, 1500 lb minimum capacity
Operator compartment wiring harness removed
7/8-14NC, 3 in. lifting links
(WP 0106 00)
Materials/Parts
Transmission shift control cable removed (WP
Cap set, protective (Item 6, WP 0339 00)
0125 00)
Cleaning compound, solvent (Item 8, WP 0339 00)
Transmission shift control lever and housing
Detergent (Item 13, WP 0339 00)
removed (WP 0126 00)
Rag, wiping (Item 35, WP 0339 00)
Brake retarder air lines removed (WP 0141 00)
Tag, marker (Item 42, WP 0339 00)
Brake hoses and fittings removed (WP 0162 00,
Gasket (5)
WP 0163 00, WP 0169 00)
Packing, preformed (3)
Brake control valve removed (WP 0155 00)
Seal
Double check valve removed (WP 0158 00)
References
Brake control valve lines and fittings removed (WP
TM 5-3805-248-10
0161 00)
Personnel Required
Air dryer removed (WP 0152 00)
Two
Tractor air tanks removed (WP 0153 00)
Equipment Condition
Steering column and shaft removed (WP 0178 00)
Transmission shift pedal removed (WP 0139 00)
Mechanical linkage removed (WP 0179 00)
Transmission shift lines and fittings removed (WP
Rollover protection system (ROPS) removed (WP
0248 00)
0203 00)
Transmission shift control valve removed (WP
Operator compartment-upper front access plates
0174 00)
removed (WP 0192 00)
Differential lock pedal removed (WP 0171 00)
Operator compartment-side panel plate removed
(WP 0195 00)
Differential lock lines and fittings removed (WP
0172 00)
Floormat and step removed (WP 0198 00)
Left fender removed (WP 0205 00)
Differential lock control valve assembly removed
(WP 0173 00)
Seat assembly removed (WP 0211 00)
Scraper hydraulic controls, levers and linkage
Air horn assembly removed (WP 0218 00)
removed (WP 0222 00)
Tachometer drive cable removed (WP 0248 00)
Left panel removed (WP 0071 00)
Non-electrical gages lines and fittings removed
Right panel removed (WP 0072 00)
(WP 0249 00, WP 0250 00)
Fuse block removed (WP 0075 00)
Governor control removed (WP 0280 00)
Battery disconnect switch removed (WP 0074 00)
Low air removed (WP 0099 00)
